- Vehicles
- 23,839
- Built between
- Not published
- Models
- 2
- Recall type
- Vehicle
- Initiated by
- Manufacturer
- Owners notified
- 6 January 2006
- Repaired
- Not reported
- Unrepaired
- Not reported
Does this affect my vehicle?
The manufacturer did not publish a build-date range for this recall, so the model and year list below is the only way to tell whether your vehicle is covered.
- 2005-2006 Suzuki VL800
- 2005-2006 Suzuki VZ800
What the defect is
On certain motorcycles, the ignition switch wiring harness may have been improperly routed at the time of production. If the wiring harness is not routed properly, it can rub against the clutch cable/throttle cable.
What could happen
Continued rubbing may eventually lead to a short circuit which may cause the engine to stall or the lights to go out. This will increase the chance of a crash resulting in serious injury or death.
What gets fixed
DEALERS WILL RE-ROUTE THE IGNITION SWITCH WIRING HARNESS AND REPLACE THE LOCK SET INCLUDING THE IGNITION SWITCH ALONG WITH THE CLUTCH CABLE/THROTTLE CABLE FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 6, 2006.
Timeline
- Recall reported to NHTSA21 December 2005
- Owners notified6 January 2006
Your rights
A safety recall repair is free. Under US federal law the manufacturer must fix a safety defect at no cost to you — no charge for parts, labor or diagnosis — whether or not you are the original owner. A dealer cannot charge you for recall work, and cannot require you to have bought the vehicle from them.
That entitlement is not unlimited. It applies where the vehicle was first sold less than 15 years before the recall was announced — 5 years for tires. Past that a manufacturer may still do the repair free of charge, and many do, but they are no longer obliged to. This recall was reported on 21 December 2005.
To arrange the repair, contact any franchised dealer for the brand. If a dealer refuses the work or tries to charge for it, you can report that to NHTSA at nhtsa.gov/recalls or on 1-888-327-4236.
Manufacturer contact
Owners may contact suzuki at 714-572-1490.
Official source
- Manufacturer's recall number
- 2085
- Recalling manufacturer
- AMERICAN SUZUKI MOTOR CORP.
- Recall initiated by
- MFR
Everything on this page — the models listed, the build dates and the repair figures — comes from the manufacturer's filing to NHTSA and describes the vehicle line as a whole, not any individual car. Only the manufacturer can confirm whether a specific vehicle is affected, and whether its recall work has already been carried out. Check yours by VIN and read the official notice at nhtsa.gov/recalls.
Additional notes
Suzuki recall no. 2085.CUSTOMERS may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Check your own vehicle
This page describes the recall, not any one car. To see which recalls cover a specific vehicle, search by make, model and year.
A VIN lookup here identifies your vehicle and shows recalls issued for that make, model and year. It cannot tell you what is still open on your individual car - only the manufacturer knows that. Search by VIN instead, or check your VIN at nhtsa.gov for whether a recall is still open on your individual car.