- Vehicles
- 292
- Built between
- Not published
- Models
- 4
- Recall type
- Equipment
- Initiated by
- NHTSA investigation
- Owners notified
- Not yet
- Repaired
- Not reported
- Unrepaired
- Not reported
Does this affect my vehicle?
The manufacturer did not publish a build-date range for this recall, so the model and year list below is the only way to tell whether your vehicle is covered.
- Fifth Wheel Simplex
- 2007 Kenworth T600
- 2007 Kenworth T800
- 2007 Kenworth W900
What the defect is
Paccar is recalling 292 aftermarket saf holland fifth wheels sold for use on my 2007 kenworth T800 short hood, W900 long hood and T600 tractor/trailers. If the pivot bolt joint for the lever bar is over torqued, the spacer deforms, and makes contact with the lever bar. This condition coupled with corrosion associated with the seasonal dry out, can affect the lock system of the fifth wheel, preventing the fifth wheel jaw from latching securely around the trailer king pin.
What could happen
The fifth wheel may fail to latch without the operator's knowledge, causing the tractor and trailer to disengage increasing the risk of a crash.
What gets fixed
PACCAR IS WORKING WITH SAF-HOLLAND AND WILL INSPECT THE PIVOT BOLT JOINT FOR A DEFORMED SPACER AND REPLACE THE BOLT, WASHER AND SPACER WITH A HEX-HEAD SHOULDER BOLT AND WASHER FREE OF CHARGE. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHECDULE.
Timeline
- Recall reported to NHTSA24 April 2008
No owner-notification date has been published yet. Manufacturers normally write to registered owners within 60 days of reporting a recall.
Your rights
A safety recall repair is free. Under US federal law the manufacturer must fix a safety defect at no cost to you — no charge for parts, labor or diagnosis — whether or not you are the original owner. A dealer cannot charge you for recall work, and cannot require you to have bought the vehicle from them.
That entitlement is not unlimited. It applies where the vehicle was first sold less than 15 years before the recall was announced — 5 years for tires. Past that a manufacturer may still do the repair free of charge, and many do, but they are no longer obliged to. This recall was reported on 24 April 2008.
To arrange the repair, contact any franchised dealer for the brand. If a dealer refuses the work or tries to charge for it, you can report that to NHTSA at nhtsa.gov/recalls or on 1-888-327-4236.
Manufacturer contact
Owners may contact paccar at 1-415-828-5000 or saf-holland at 1-231-773-3271.
Official source
- Manufacturer's recall number
- 08KW7
- Recalling manufacturer
- PACCAR INCORPORATED
- Recall initiated by
- ODI
Everything on this page — the models listed, the build dates and the repair figures — comes from the manufacturer's filing to NHTSA and describes the vehicle line as a whole, not any individual car. Only the manufacturer can confirm whether a specific vehicle is affected, and whether its recall work has already been carried out. Check yours by VIN and read the official notice at nhtsa.gov/recalls.
Additional notes
Paccar recall no. 08KW7.CUSTOMERS may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Check your own vehicle
This page describes the recall, not any one car. To see which recalls cover a specific vehicle, search by make, model and year.
A VIN lookup here identifies your vehicle and shows recalls issued for that make, model and year. It cannot tell you what is still open on your individual car - only the manufacturer knows that. Search by VIN instead, or check your VIN at nhtsa.gov for whether a recall is still open on your individual car.