- Vehicles
- 31
- Built between
- May 2007 – Mar 2008
- Models
- 3
- Recall type
- Vehicle
- Initiated by
- Manufacturer
- Owners notified
- Not yet
- Repaired
- Not reported
- Unrepaired
- Not reported
Does this affect my vehicle?
This recall covers vehicles built between May 2007 and March 2008. If yours was built outside that window, it is not part of this recall.
- 2007-2008 Champion ChallengerBuilt May 2007 to March 2008
- 2008 Champion CrusaderBuilt May 2007 to March 2008
- 2007-2008 Champion DefenderBuilt May 2007 to March 2008
What the defect is
Champion bus is recalling 31 my 2007-2008 defender, challenger and my 2008 crusader buses built on general motors 560 chassis and equipped with intermotive gateway 401 module interlock harness. These buses have been found to exhibit extreme voltage spikes during engine cranking. These extreme spikes can damage the diode in the harness near the shift lock solenoid connector. If the diode fails in the shorted condition, the gateway 401 module can be damaged.
What could happen
If this occurs, the shift lock solenoid may not engage. If this lock does not engage, the vehicle will have the ability to move while the wheelchair lift is deployed which may result in personal injury.
What gets fixed
INTERMOTIVE IS HANDLING THE REMEDY FOR THIS CAMPAIGN (PLEASE SEE 08E004). INTERMOTIVE WILL REPLACE THE DEFECTIVE HARNESS FREE OF CHARGE.
Timeline
- Vehicles builtMay 2007 to March 2008
- Recall reported to NHTSA19 May 2008
No owner-notification date has been published yet. Manufacturers normally write to registered owners within 60 days of reporting a recall.
Your rights
A safety recall repair is free. Under US federal law the manufacturer must fix a safety defect at no cost to you — no charge for parts, labor or diagnosis — whether or not you are the original owner. A dealer cannot charge you for recall work, and cannot require you to have bought the vehicle from them.
That entitlement is not unlimited. It applies where the vehicle was first sold less than 15 years before the recall was announced — 5 years for tires. Past that a manufacturer may still do the repair free of charge, and many do, but they are no longer obliged to. This recall was reported on 19 May 2008.
To arrange the repair, contact any franchised dealer for the brand. If a dealer refuses the work or tries to charge for it, you can report that to NHTSA at nhtsa.gov/recalls or on 1-888-327-4236.
Manufacturer contact
Owners may contact intermotive at 1-800-969-6080 or champion bus at 1-810-724-6474.
Official source
- Recalling manufacturer
- CHAMPION BUS, INC.
- Safety standard
- FMVSS 120
- Recall initiated by
- MFR
Everything on this page — the models listed, the build dates and the repair figures — comes from the manufacturer's filing to NHTSA and describes the vehicle line as a whole, not any individual car. Only the manufacturer can confirm whether a specific vehicle is affected, and whether its recall work has already been carried out. Check yours by VIN and read the official notice at nhtsa.gov/recalls.
Additional notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Check your own vehicle
This page describes the recall, not any one car. To see which recalls cover a specific vehicle, search by make, model and year.
A VIN lookup here identifies your vehicle and shows recalls issued for that make, model and year. It cannot tell you what is still open on your individual car - only the manufacturer knows that. Search by VIN instead, or check your VIN at nhtsa.gov for whether a recall is still open on your individual car.