- Vehicles
- 196,222
- Built between
- Not published
- Models
- 1
- Recall type
- Vehicle
- Initiated by
- NHTSA investigation
- Owners notified
- 4 August 2008
- Repaired
- Not reported
- Unrepaired
- Not reported
Does this affect my vehicle?
The manufacturer did not publish a build-date range for this recall, so the model and year list below is the only way to tell whether your vehicle is covered.
- 2004-2006 Toyota Sienna
What the defect is
Toyota is conducting a safety improvement campaign involving 196,222 my 2004-2006 toyota sienna vehicles equipped with power rear liftgate struts. The gas struts used to help lift and support the rear power liftgate could wear out sooner than expected. As the gas struts deteriorate, the performance of the liftgate will begin to degrade and the power rear liftgate will operate more slowly than when the gas struts were new.
What could happen
If not repaired, the gas struts may not be able to support the weight of the liftgate when it is open eventually, the gas struts could deteriorate to the point that the liftgate will fall about ten inches after it reaches the fully open position, at which point the power motor will engage and power the liftgate to the fully closed position. This condition may cause injury to a person who is struck by the liftgate when it falls or when it is closing.
What gets fixed
DEALERS WILL REPLACE THE GAS STRUTS WITH NEWLY DESIGNED GAS STRUTS THAT HAVE A LONGER SERVICE LIFE. THE CAMPAIGN BEGAN ON AUGUST 8, 2008, AND WILL BE MAILED IN THREE PHASES ENDING IN LATE DECEMBER 2008.
Timeline
- Recall reported to NHTSA3 June 2008
- Owners notified4 August 2008
Your rights
A safety recall repair is free. Under US federal law the manufacturer must fix a safety defect at no cost to you — no charge for parts, labor or diagnosis — whether or not you are the original owner. A dealer cannot charge you for recall work, and cannot require you to have bought the vehicle from them.
That entitlement is not unlimited. It applies where the vehicle was first sold less than 15 years before the recall was announced — 5 years for tires. Past that a manufacturer may still do the repair free of charge, and many do, but they are no longer obliged to. This recall was reported on 3 June 2008.
To arrange the repair, contact any franchised dealer for the brand. If a dealer refuses the work or tries to charge for it, you can report that to NHTSA at nhtsa.gov/recalls or on 1-888-327-4236.
Manufacturer contact
Owners may contact toyota at 1-888-270-9371.
Official source
- Manufacturer's recall number
- 80C
- Recalling manufacturer
- TOYOTA MOTOR NORTH AMERICA, INC.
- Recall initiated by
- ODI
Everything on this page — the models listed, the build dates and the repair figures — comes from the manufacturer's filing to NHTSA and describes the vehicle line as a whole, not any individual car. Only the manufacturer can confirm whether a specific vehicle is affected, and whether its recall work has already been carried out. Check yours by VIN and read the official notice at nhtsa.gov/recalls.
Additional notes
Toyota no. 80C.THIS action is deemed a safety improvement campaign and is not being conducted under the safety act. However, toyota has informed NHTSA that it will provide the modifications described above free of charge.
Check your own vehicle
This page describes the recall, not any one car. To see which recalls cover a specific vehicle, search by make, model and year.
A VIN lookup here identifies your vehicle and shows recalls issued for that make, model and year. It cannot tell you what is still open on your individual car - only the manufacturer knows that. Search by VIN instead, or check your VIN at nhtsa.gov for whether a recall is still open on your individual car.