- Vehicles
- 215
- Built between
- May 2007 – May 2008
- Models
- 3
- Recall type
- Vehicle
- Initiated by
- Manufacturer
- Owners notified
- 12 June 2008
- Repaired
- Not reported
- Unrepaired
- Not reported
Does this affect my vehicle?
This recall covers vehicles built between May 2007 and May 2008. If yours was built outside that window, it is not part of this recall.
- 2008 Ford F-350 CutawayBuilt May 2007 to May 2008
- 2008 Ford F-450 CutawayBuilt May 2007 to April 2008
- 2008 Ford F-550 CutawayBuilt December 2007 to December 2007
What the defect is
Wheeled coach is recalling 215 my 2008 F-350, F-450, and F-550 rescue vehicles built on ford chassis and equipped with 6.4L diesel engines. It has been determined that the connection of the master switch yellow 16GA wire to the OEM PTO enable circuit disrupts the regeneration mode when the master switch is in the "on" position. The regeneration mode failure will eventually cause the 6.4L diesel engine to reduce power and enter in to a limp home mode.
What could happen
The regeneration mode failure will cause the 6.4L diesel engine to reduce power increasing the risk of a crash.
What gets fixed
WHEELED COACH WILL MAIL OUT RELAY KITS ALONG WITH INSTALLATION INSTRUCTIONS. CUSTOMERS CAN ALSO TAKE THEIR VEHICLE TO A SERVICE CENTER TO HAVE THE RELAY INSTALLED IF THEY SO DESIRE. THE RECALL BEGAN ON JUNE 12, 2008.
Timeline
- Vehicles builtMay 2007 to May 2008
- Recall reported to NHTSA27 June 2008
- Owners notified12 June 2008
Your rights
A safety recall repair is free. Under US federal law the manufacturer must fix a safety defect at no cost to you — no charge for parts, labor or diagnosis — whether or not you are the original owner. A dealer cannot charge you for recall work, and cannot require you to have bought the vehicle from them.
That entitlement is not unlimited. It applies where the vehicle was first sold less than 15 years before the recall was announced — 5 years for tires. Past that a manufacturer may still do the repair free of charge, and many do, but they are no longer obliged to. This recall was reported on 27 June 2008.
To arrange the repair, contact any franchised dealer for the brand. If a dealer refuses the work or tries to charge for it, you can report that to NHTSA at nhtsa.gov/recalls or on 1-888-327-4236.
Manufacturer contact
Owners may contact wheeled coach at 1-800-932-7077.
Official source
- Recalling manufacturer
- WHEELED COACH INDUSTRIES
- Recall initiated by
- MFR
Everything on this page — the models listed, the build dates and the repair figures — comes from the manufacturer's filing to NHTSA and describes the vehicle line as a whole, not any individual car. Only the manufacturer can confirm whether a specific vehicle is affected, and whether its recall work has already been carried out. Check yours by VIN and read the official notice at nhtsa.gov/recalls.
Additional notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Check your own vehicle
This page describes the recall, not any one car. To see which recalls cover a specific vehicle, search by make, model and year.
A VIN lookup here identifies your vehicle and shows recalls issued for that make, model and year. It cannot tell you what is still open on your individual car - only the manufacturer knows that. Search by VIN instead, or check your VIN at nhtsa.gov for whether a recall is still open on your individual car.