- Vehicles
- 14,551
- Built between
- Jan 2003 – Jan 2004
- Models
- 1
- Recall type
- Vehicle
- Initiated by
- Manufacturer
- Owners notified
- 1 June 2009
- Repaired
- Not reported
- Unrepaired
- Not reported
Does this affect my vehicle?
This recall covers vehicles built between January 2003 and January 2004. If yours was built outside that window, it is not part of this recall.
- 2004 Jaguar XJBuilt January 2003 to January 2004
What the defect is
Jaguar is recalling 14,551 my 2004 xj vehicles. A potential concern has been identified with the installation of a noise vibration and harshness (nvh) pad fitted to the under tray and its interaction with the rear under floor brake pipes, rear cross member brake pipes, and their unions. A review of vehicle build conditions provides evidence that a touch condition can exist between the under floor and cross member brake pipes and the nvh pad at the rear of the under floor under tray. Where the touch condition exists, water and dirt can collect and be held in contact with the pipes and their unions, abrade the corrosion protection and reduce the corrosion life of the pipes accordingly.
What could happen
Corrosion of the brake pipes can lead to a loss of mechanical integrity of the braking system. This can result in extended brake pedal travel combined with reduced braking performance in the corresponding brake circuit. The instrument cluster may display the warning message 'fluid level low', along with the brake warning lamp being illuminated. In the event of both braking circuits losing integrity at the same time, complete loss of service brakes will occur, thereby potentially causing a vehicle crash.
What gets fixed
DEALERS WILL REMOVE THE UNDER TRAY AT THE REAR OF THE VEHICLE AND REMOVE AND DISCARD THE NVH PAD FITTED TO THE REAR OF THE UNDER TRAY. DEALERS WILL INSPECT THE REAR UNDER FLOOR AND REAR CROSS MEMBER BRAKE PIPES AND UNIONS FOR RED RUST. IF RED RUST IS PRESENT ON THE PIPES OR ON THE UNION, THE BRAKE PIPES AND UNION WILL BE REPLACED WITH NEW COMPONENTS OF THE SAME DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009.
Timeline
- Vehicles builtJanuary 2003 to January 2004
- Recall reported to NHTSA30 April 2009
- Owners notified1 June 2009
Your rights
A safety recall repair is free. Under US federal law the manufacturer must fix a safety defect at no cost to you — no charge for parts, labor or diagnosis — whether or not you are the original owner. A dealer cannot charge you for recall work, and cannot require you to have bought the vehicle from them.
That entitlement is not unlimited. It applies where the vehicle was first sold less than 15 years before the recall was announced — 5 years for tires. Past that a manufacturer may still do the repair free of charge, and many do, but they are no longer obliged to. This recall was reported on 30 April 2009.
To arrange the repair, contact any franchised dealer for the brand. If a dealer refuses the work or tries to charge for it, you can report that to NHTSA at nhtsa.gov/recalls or on 1-888-327-4236.
Manufacturer contact
Owners may contact jaguar at 1-800-452-4827.
Official source
- Manufacturer's recall number
- J012
- Recalling manufacturer
- JAGUAR CARS LTD
- Recall initiated by
- MFR
Everything on this page — the models listed, the build dates and the repair figures — comes from the manufacturer's filing to NHTSA and describes the vehicle line as a whole, not any individual car. Only the manufacturer can confirm whether a specific vehicle is affected, and whether its recall work has already been carried out. Check yours by VIN and read the official notice at nhtsa.gov/recalls.
Additional notes
Jaguar recall no. J012.OWNERS may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Check your own vehicle
This page describes the recall, not any one car. To see which recalls cover a specific vehicle, search by make, model and year.
A VIN lookup here identifies your vehicle and shows recalls issued for that make, model and year. It cannot tell you what is still open on your individual car - only the manufacturer knows that. Search by VIN instead, or check your VIN at nhtsa.gov for whether a recall is still open on your individual car.