- Vehicles
- 12
- Built between
- Aug 2009 – Dec 2010
- Models
- 1
- Recall type
- Vehicle
- Initiated by
- Manufacturer
- Owners notified
- 23 December 2010
- Repaired
- Not reported
- Unrepaired
- Not reported
Does this affect my vehicle?
This recall covers vehicles built between August 2009 and December 2010. If yours was built outside that window, it is not part of this recall.
- 2010-2011 General Coach ABC - M1235Built August 2009 to December 2010
What the defect is
Champion bus is recalling certain vehicles built on freightliner S2 chassis and equipped with trw IGEN3 intermediate steering columns. The weld around the IGEN3 steering shaft tube that secures the spline tube to the intermediate tube may be mislocated (i.e., not fully over the seam created when the tubes are pressed together.)
What could happen
Mislocated welds may result in torsional and axial strength falling below acceptable levels. This condition could result in separation of the steering column, loss of steering control and a vehicle crash without warning.
What gets fixed
DAIMLER TRUCKS/FREIGHTLINER WILL HANDLE THE REMEDY AND QUARTERLY REPORTS FOR THIS CAMPAIGN. PLEASE SEE FREIGHTLINER'S DEFECT REPORT (10V-322). FREIGHTLINER WILL NOTIFY OWNERS AND THE BUSES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 23, 2010.
Timeline
- Vehicles builtAugust 2009 to December 2010
- Recall reported to NHTSA21 December 2010
- Owners notified23 December 2010
Your rights
A safety recall repair is free. Under US federal law the manufacturer must fix a safety defect at no cost to you — no charge for parts, labor or diagnosis — whether or not you are the original owner. A dealer cannot charge you for recall work, and cannot require you to have bought the vehicle from them.
That entitlement is not unlimited. It applies where the vehicle was first sold less than 15 years before the recall was announced — 5 years for tires. Past that a manufacturer may still do the repair free of charge, and many do, but they are no longer obliged to. This recall was reported on 21 December 2010.
To arrange the repair, contact any franchised dealer for the brand. If a dealer refuses the work or tries to charge for it, you can report that to NHTSA at nhtsa.gov/recalls or on 1-888-327-4236.
Manufacturer contact
Owners may contact daimler trucks/freightliner at 1-800-547-0712.
Official source
- Recalling manufacturer
- CHAMPION BUS, INC.
- Recall initiated by
- MFR
Everything on this page — the models listed, the build dates and the repair figures — comes from the manufacturer's filing to NHTSA and describes the vehicle line as a whole, not any individual car. Only the manufacturer can confirm whether a specific vehicle is affected, and whether its recall work has already been carried out. Check yours by VIN and read the official notice at nhtsa.gov/recalls.
Additional notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Check your own vehicle
This page describes the recall, not any one car. To see which recalls cover a specific vehicle, search by make, model and year.
A VIN lookup here identifies your vehicle and shows recalls issued for that make, model and year. It cannot tell you what is still open on your individual car - only the manufacturer knows that. Search by VIN instead, or check your VIN at nhtsa.gov for whether a recall is still open on your individual car.