- Vehicles
- 1,165
- Built between
- Not published
- Models
- 2
- Recall type
- Equipment
- Initiated by
- Manufacturer
- Owners notified
- 1 March 2012
- Repaired
- Not reported
- Unrepaired
- Not reported
Does this affect my vehicle?
The manufacturer did not publish a build-date range for this recall, so the model and year list below is the only way to tell whether your vehicle is covered.
- Carlisle Hydrastar
- Carlisle Hydrastar XL
What the defect is
Carlisle brake and friction company is recalling certain hydrastar and hydrastar xl trailer brake actuators produced from october 5, 2011, through december 9, 2011. One of the rotating components in the hydraulic pump missed a heat treat operation causing the actuator to wear at a higher than normal rate. As a result, the hydraulic pump could fail and result in a loss of braking ability in the trailer.
What could happen
Loss of braking ability can lead to loss of control of the trailer, increasing the risk of a crash, serious injuries, or property damage.
What gets fixed
CARLISLE BRAKE AND FRICTION COMPANY WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE HYDRAULIC PUMPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 1, 2012.
Timeline
- Recall reported to NHTSA1 February 2012
- Owners notified1 March 2012
Your rights
A safety recall repair is free. Under US federal law the manufacturer must fix a safety defect at no cost to you — no charge for parts, labor or diagnosis — whether or not you are the original owner. A dealer cannot charge you for recall work, and cannot require you to have bought the vehicle from them.
That entitlement is not unlimited. It applies where the vehicle was first sold less than 15 years before the recall was announced — 5 years for tires. Past that a manufacturer may still do the repair free of charge, and many do, but they are no longer obliged to. This recall was reported on 1 February 2012.
To arrange the repair, contact any franchised dealer for the brand. If a dealer refuses the work or tries to charge for it, you can report that to NHTSA at nhtsa.gov/recalls or on 1-888-327-4236.
Manufacturer contact
Owners may contact carlisle brake and friction company at 1-800-542-0972.
Official source
- Recalling manufacturer
- CARLISLE BRAKE AND FRICTION COMPANY
- Recall initiated by
- MFR
Everything on this page — the models listed, the build dates and the repair figures — comes from the manufacturer's filing to NHTSA and describes the vehicle line as a whole, not any individual car. Only the manufacturer can confirm whether a specific vehicle is affected, and whether its recall work has already been carried out. Check yours by VIN and read the official notice at nhtsa.gov/recalls.
Additional notes
Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Check your own vehicle
This page describes the recall, not any one car. To see which recalls cover a specific vehicle, search by make, model and year.
A VIN lookup here identifies your vehicle and shows recalls issued for that make, model and year. It cannot tell you what is still open on your individual car - only the manufacturer knows that. Search by VIN instead, or check your VIN at nhtsa.gov for whether a recall is still open on your individual car.