- Vehicles
- 23
- Built between
- Dec 2014 – Jun 2015
- Models
- 2
- Recall type
- Vehicle
- Initiated by
- Manufacturer
- Owners notified
- 16 December 2015
- Repaired
- 100%
- Unrepaired
- 0
Does this affect my vehicle?
This recall covers vehicles built between December 2014 and June 2015. If yours was built outside that window, it is not part of this recall.
- 2014-2015 Spartan Defense Dept. Chassis CABBuilt December 2014 to June 2015
- 2014-2015 Spartan MetrostarBuilt December 2014 to June 2015
Repair progress
The manufacturer reports every reachable vehicle in this recall has been repaired, as of Q1 2017.
100% repaired — 23 of 23 reported
Manufacturers file these figures with NHTSA each quarter. Vehicles the manufacturer could not trace, or that have been scrapped or exported, are counted separately and are not included in the unrepaired figure.
What the defect is
Spartan Motors USA (Spartan) is recalling certain model year 2014-2015 MetroStar Chassis cabs built for Emergency Response use and ILAV Chassis cabs for Department of Defense use, manufactured December 9, 2014 to June 3, 2015 and equipped with certain drive axles manufactured by Marmon-Herrington. The affected axles have hex nuts on the flange yoke that may not have been properly tightened.
What could happen
If the hex nuts are not tightened to specification, the driveshaft may disconnect from the drive axle, resulting in a loss of propulsion and increasing the risk of a crash.
What gets fixed
Spartan will notify owners and dealers will inspect the hex nuts, tightening them as necessary, free of charge. The recall began on December 16, 2015.
Timeline
- Vehicles builtDecember 2014 to June 2015
- Recall reported to NHTSA10 November 2015
- Owners notified16 December 2015
- Latest repair reportQ1 2017 — 100% repaired
Your rights
A safety recall repair is free. Under US federal law the manufacturer must fix a safety defect at no cost to you — no charge for parts, labor or diagnosis — whether or not you are the original owner. A dealer cannot charge you for recall work, and cannot require you to have bought the vehicle from them.
That entitlement is not unlimited. It applies where the vehicle was first sold less than 15 years before the recall was announced — 5 years for tires. Past that a manufacturer may still do the repair free of charge, and many do, but they are no longer obliged to. This recall was reported on 10 November 2015.
To arrange the repair, contact any franchised dealer for the brand. If a dealer refuses the work or tries to charge for it, you can report that to NHTSA at nhtsa.gov/recalls or on 1-888-327-4236.
Manufacturer contact
Owners may contact Marmon Herrington customer service at 1-517-543-6400 or contact Spartan customer service at 1-800-543-4277.
Official source
- Manufacturer's recall number
- 15026
- Recalling manufacturer
- Spartan Motors USA
- Recall initiated by
- MFR
Everything on this page — the models listed, the build dates and the repair figures — comes from the manufacturer's filing to NHTSA and describes the vehicle line as a whole, not any individual car. Only the manufacturer can confirm whether a specific vehicle is affected, and whether its recall work has already been carried out. Check yours by VIN and read the official notice at nhtsa.gov/recalls.
Additional notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Check your own vehicle
This page describes the recall, not any one car. To see which recalls cover a specific vehicle, search by make, model and year.
A VIN lookup here identifies your vehicle and shows recalls issued for that make, model and year. It cannot tell you what is still open on your individual car - only the manufacturer knows that. Search by VIN instead, or check your VIN at nhtsa.gov for whether a recall is still open on your individual car.