- Vehicles
- 28
- Built between
- Not published
- Models
- 2
- Recall type
- Vehicle
- Initiated by
- Manufacturer
- Owners notified
- 5 September 2024
- Repaired
- 100%
- Unrepaired
- 0
Does this affect my vehicle?
The manufacturer did not publish a build-date range for this recall, so the model and year list below is the only way to tell whether your vehicle is covered.
- 2021-2023 Motiv E-450 BEV Chassis School BUS
- 2020 Motiv F-59 BEV Chassis School BUS
Repair progress
The manufacturer reports every reachable vehicle in this recall has been repaired, as of Q3 2024.
100% repaired — 28 of 28 reported
Manufacturers file these figures with NHTSA each quarter. Vehicles the manufacturer could not trace, or that have been scrapped or exported, are counted separately and are not included in the unrepaired figure.
What the defect is
Motiv Power Systems, Inc. (Motiv) is recalling certain 2021-2023 F-450 and 2020 F-59 school buses equipped with a Motiv Gen 5 EPIC powertrain. The vehicle control software could misclassify a loss of isolation between the chassis and high voltage system, shutting down the high voltage (HV) batteries.
What could happen
The shutdown of the HV batteries can cause a loss of steering and brake power assist, and drive power, increasing the risk of a crash.
What gets fixed
Motiv will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 5, 2024.
This recall is fixed by a software update. The manufacturer reports the remedy can be delivered over the air, so affected vehicles may not need a dealer visit. Confirm with the manufacturer before assuming yours has received it.
Timeline
- Recall reported to NHTSA12 August 2024
- Owners notified5 September 2024
- Latest repair reportQ3 2024 — 100% repaired
Your rights
A safety recall repair is free. Under US federal law the manufacturer must fix a safety defect at no cost to you — no charge for parts, labor or diagnosis — whether or not you are the original owner. A dealer cannot charge you for recall work, and cannot require you to have bought the vehicle from them.
That entitlement is not unlimited. It applies where the vehicle was first sold less than 15 years before the recall was announced — 5 years for tires. Past that a manufacturer may still do the repair free of charge, and many do, but they are no longer obliged to. This recall was reported on 12 August 2024.
To arrange the repair, contact any franchised dealer for the brand. If a dealer refuses the work or tries to charge for it, you can report that to NHTSA at nhtsa.gov/recalls or on 1-888-327-4236.
Manufacturer contact
Owners may contact Motiv customer service at 1-650-458-4804.
Official source
- Recalling manufacturer
- Motiv Power Systems
- Recall initiated by
- MFR
Everything on this page — the models listed, the build dates and the repair figures — comes from the manufacturer's filing to NHTSA and describes the vehicle line as a whole, not any individual car. Only the manufacturer can confirm whether a specific vehicle is affected, and whether its recall work has already been carried out. Check yours by VIN and read the official notice at nhtsa.gov/recalls.
Additional notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Check your own vehicle
This page describes the recall, not any one car. To see which recalls cover a specific vehicle, search by make, model and year.
A VIN lookup here identifies your vehicle and shows recalls issued for that make, model and year. It cannot tell you what is still open on your individual car - only the manufacturer knows that. Search by VIN instead, or check your VIN at nhtsa.gov for whether a recall is still open on your individual car.