- Vehicles
- 105
- Built between
- May 1998 – May 1999
- Models
- 1
- Recall type
- Vehicle
- Initiated by
- Manufacturer
- Owners notified
- 27 September 1999
- Repaired
- Not reported
- Unrepaired
- Not reported
Does this affect my vehicle?
This recall covers vehicles built between May 1998 and May 1999. If yours was built outside that window, it is not part of this recall.
- 1998-1999 Navistar 3800Built May 1998 to May 1999
What the defect is
Vehicle description: transit and school buses built with ABS air brake ECU and a 100 gallon fuel tank mounted between the rails and behind the rear axle on models with a 276" wheel base. The ABS ECU interfered with the cross member mounted behind the rear axle and in front of the between the rails fuel tank. This created a no-build situation at the plant - the plant would either eliminate or relocate the cross member or move the ECU as needed.
What could happen
If the cross member is either missing or relocated the vehicle may not have adequate fuel tank protection. In the event of a crash, the bus may not have adequate fuel tank protection if the vehicle has a missing or improperly installed crossmember.
What gets fixed
DEALERS WILL INSPECT THE VEHICLES TO MAKE SURE ALL CROSS MEMBERS ARE PROPERLY INSTALLED. IF THE CROSS MEMBER IS NOT INSTALLED CORRECTLY OR IS MISSING, THE DEALER WILL REPAIR OR INSTALL THE CROSS MEMBER.
Timeline
- Vehicles builtMay 1998 to May 1999
- Recall reported to NHTSA21 September 1999
- Owners notified27 September 1999
Your rights
A safety recall repair is free. Under US federal law the manufacturer must fix a safety defect at no cost to you — no charge for parts, labor or diagnosis — whether or not you are the original owner. A dealer cannot charge you for recall work, and cannot require you to have bought the vehicle from them.
That entitlement is not unlimited. It applies where the vehicle was first sold less than 15 years before the recall was announced — 5 years for tires. Past that a manufacturer may still do the repair free of charge, and many do, but they are no longer obliged to. This recall was reported on 21 September 1999.
To arrange the repair, contact any franchised dealer for the brand. If a dealer refuses the work or tries to charge for it, you can report that to NHTSA at nhtsa.gov/recalls or on 1-888-327-4236.
Official source
- Manufacturer's recall number
- 99509
- Recalling manufacturer
- INTERNATIONAL TRUCK AND ENGINE
- Recall initiated by
- MFR
Everything on this page — the models listed, the build dates and the repair figures — comes from the manufacturer's filing to NHTSA and describes the vehicle line as a whole, not any individual car. Only the manufacturer can confirm whether a specific vehicle is affected, and whether its recall work has already been carried out. Check yours by VIN and read the official notice at nhtsa.gov/recalls.
Additional notes
International recall no. 99509. Owner notification began september 27, 1999. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact navistar at 1-800-448-7825.ALSO contact the national highway traffic safety administration's auto safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).
Check your own vehicle
This page describes the recall, not any one car. To see which recalls cover a specific vehicle, search by make, model and year.
A VIN lookup here identifies your vehicle and shows recalls issued for that make, model and year. It cannot tell you what is still open on your individual car - only the manufacturer knows that. Search by VIN instead, or check your VIN at nhtsa.gov for whether a recall is still open on your individual car.