- Vehicles
- 40
- Built between
- Not published
- Models
- 7
- Recall type
- Vehicle
- Initiated by
- NHTSA investigation
- Owners notified
- 12 September 2005
- Repaired
- Not reported
- Unrepaired
- Not reported
Does this affect my vehicle?
The manufacturer did not publish a build-date range for this recall, so the model and year list below is the only way to tell whether your vehicle is covered.
- 2001-2004 Us Bus SBCX59
- 2002, 2004 Us Bus SD
- 2001, 2003-2004 Us Bus SDX
- 2001 Us Bus UC
- 2001 Us Bus UF
- 2002 Us Bus XBC
- 2002 Us Bus XUC
What the defect is
Certain 2001 through 2004 US bus school buses. In extremely cold weather, the microswitches used internally to position the sign in the open and closed positions may malfunction, causing the sign to open or close in an improper position, or to not open at all.
What could happen
Should the stop arm not perform properly, a child or pedestrian may be endangered by passing vehicles should the motorist not stop at the correct location.
What gets fixed
US BUS WILL NOTIFY ITS CUSTOMERS AND SPECIALTY MFG. WILL PROVIDE FREE OF CHARGE A SERVICE KIT (PART NUMBER 005178) WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2005.
Timeline
- Recall reported to NHTSA26 July 2005
- Owners notified12 September 2005
Your rights
A safety recall repair is free. Under US federal law the manufacturer must fix a safety defect at no cost to you — no charge for parts, labor or diagnosis — whether or not you are the original owner. A dealer cannot charge you for recall work, and cannot require you to have bought the vehicle from them.
That entitlement is not unlimited. It applies where the vehicle was first sold less than 15 years before the recall was announced — 5 years for tires. Past that a manufacturer may still do the repair free of charge, and many do, but they are no longer obliged to. This recall was reported on 26 July 2005.
To arrange the repair, contact any franchised dealer for the brand. If a dealer refuses the work or tries to charge for it, you can report that to NHTSA at nhtsa.gov/recalls or on 1-888-327-4236.
Manufacturer contact
Owners may contact specialty mfg. At 800-951-7867 or US bus 1-765-939-3984.
Official source
- Recalling manufacturer
- U.S. BUS CORPORATION
- Recall initiated by
- ODI
Everything on this page — the models listed, the build dates and the repair figures — comes from the manufacturer's filing to NHTSA and describes the vehicle line as a whole, not any individual car. Only the manufacturer can confirm whether a specific vehicle is affected, and whether its recall work has already been carried out. Check yours by VIN and read the official notice at nhtsa.gov/recalls.
Additional notes
Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236; (TTY:1-800-424-9153); or go to http://www.safercar.gov.
Check your own vehicle
This page describes the recall, not any one car. To see which recalls cover a specific vehicle, search by make, model and year.
A VIN lookup here identifies your vehicle and shows recalls issued for that make, model and year. It cannot tell you what is still open on your individual car - only the manufacturer knows that. Search by VIN instead, or check your VIN at nhtsa.gov for whether a recall is still open on your individual car.