- Vehicles
- 44,915
- Built between
- Jan 2006 – Dec 2010
- Models
- 1
- Recall type
- Equipment
- Initiated by
- NHTSA investigation
- Owners notified
- 31 January 2011
- Repaired
- Not reported
- Unrepaired
- Not reported
Does this affect my vehicle?
This recall covers vehicles built between January 2006 and December 2010. If yours was built outside that window, it is not part of this recall.
- Carrier EM-1Built January 2006 to December 2010
What the defect is
Carrier is recalling certain carrier genv EM-1 evaporator units (EM-1) manufactured from january 1, 2006 through december 2010, containing a delphi pack-con iii fuse holder in an allied motion motor assembly; EM-1 unit part numbers 77-62112-XX and 77-62512-XX, starting with serial number KNT90890232 to serial number NNE91230058, sold as aftermarket equipment and installed as original equipment on certain school and shuttle buses. Due to time, temperature, and/or vibration, the fuse may loosen in the fuse holder resulting in high resistance and arcing.
What could happen
If sufficient arcing occurs, the fuse holder may melt, and may be accompanied by flame, smoke and potential fire.
What gets fixed
CARRIER WILL NOTIFY BUS MANUFACTURERS, CARRIER AUTHORIZED DEALERS AS WELL AS, TO THE EXTENT KNOWN BY CARRIER, OWNERS OF RECORD WHICH PURCHASED THE AFFECTED UNITS. CARRIER IS WORKING WITH THE BUS MANUFACTURERS AND CARRIER AUTHORIZED DEALERS TO IDENTIFY AND NOTIFY OWNERS OF THE BUSES WHICH MAY HAVE HAD THE AFFECTED EM-1 UNIT SOLD AS ORIGINAL EQUIPMENT OR AS AN AFTERMARKET INSTALLATION. CARRIER WILL PROVIDE A RETROFIT KIT ALONG WITH REPAIR INSTRUCTIONS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 31, 2011.
Timeline
- Vehicles builtJanuary 2006 to December 2010
- Recall reported to NHTSA25 January 2011
- Owners notified31 January 2011
Your rights
A safety recall repair is free. Under US federal law the manufacturer must fix a safety defect at no cost to you — no charge for parts, labor or diagnosis — whether or not you are the original owner. A dealer cannot charge you for recall work, and cannot require you to have bought the vehicle from them.
That entitlement is not unlimited. It applies where the vehicle was first sold less than 15 years before the recall was announced — 5 years for tires. Past that a manufacturer may still do the repair free of charge, and many do, but they are no longer obliged to. This recall was reported on 25 January 2011.
To arrange the repair, contact any franchised dealer for the brand. If a dealer refuses the work or tries to charge for it, you can report that to NHTSA at nhtsa.gov/recalls or on 1-888-327-4236.
Manufacturer contact
Owners may contact their vehicle manufacturer or carrier at 1-800-793-4741.
Official source
- Recalling manufacturer
- CARRIER CORPORATION
- Recall initiated by
- ODI
Everything on this page — the models listed, the build dates and the repair figures — comes from the manufacturer's filing to NHTSA and describes the vehicle line as a whole, not any individual car. Only the manufacturer can confirm whether a specific vehicle is affected, and whether its recall work has already been carried out. Check yours by VIN and read the official notice at nhtsa.gov/recalls.
Additional notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Check your own vehicle
This page describes the recall, not any one car. To see which recalls cover a specific vehicle, search by make, model and year.
A VIN lookup here identifies your vehicle and shows recalls issued for that make, model and year. It cannot tell you what is still open on your individual car - only the manufacturer knows that. Search by VIN instead, or check your VIN at nhtsa.gov for whether a recall is still open on your individual car.