- Vehicles
- 20,689
- Built between
- Dec 1995 – Jul 1996
- Models
- 5
- Recall type
- Vehicle
- Initiated by
- Manufacturer
- Owners notified
- 18 October 1996
- Repaired
- Not reported
- Unrepaired
- Not reported
Does this affect my vehicle?
This recall covers vehicles built between December 1995 and July 1996. If yours was built outside that window, it is not part of this recall.
- 1996 Chevrolet G10Built December 1995 to July 1996
- 1996 Chevrolet G20Built December 1995 to July 1996
- 1996 Chevrolet G30Built December 1995 to July 1996
- 1996 GMC G25Built December 1995 to July 1996
- 1996 GMC G35Built December 1995 to July 1996
What the defect is
Water intrusion into the kick panel areas in front of both the driver and passenger doors can cause a corrosion path between the battery feed and the electrical ground.
What could happen
This condition can cause an electrical short leading to ignition and combusion of the plastics in the electrical components of the vehicle resulting in a vehicle fire.
What gets fixed
DEALERS WILL REPLACE THE 25 AMP CIRCUIT BREAKERS WITH 25 AMP FUSES IN THE FUSE BLOCK; REMOVE A TEMPORARY PAPER FUSE-BLOCK COVER; INSTALL A PLASTIC SHIELD OVER THE FUSE BLOCK; REPLACE AND REORIENT THE POWER DOOR LOCK RELAY (IF EQUIPPED); INSPECT THE REMOTE KEYLESS ENTRY MODULE (IF EQUIPPED) FOR SIGNS OF CORROSION, REPLACE IF CORRODED, AND REORIENT IT; AND APPLY ADDITIONAL BODY SEALER IN KEY AREAS.
Timeline
- Vehicles builtDecember 1995 to July 1996
- Recall reported to NHTSA26 September 1996
- Owners notified18 October 1996
Your rights
A safety recall repair is free. Under US federal law the manufacturer must fix a safety defect at no cost to you — no charge for parts, labor or diagnosis — whether or not you are the original owner. A dealer cannot charge you for recall work, and cannot require you to have bought the vehicle from them.
That entitlement is not unlimited. It applies where the vehicle was first sold less than 15 years before the recall was announced — 5 years for tires. Past that a manufacturer may still do the repair free of charge, and many do, but they are no longer obliged to. This recall was reported on 26 September 1996.
To arrange the repair, contact any franchised dealer for the brand. If a dealer refuses the work or tries to charge for it, you can report that to NHTSA at nhtsa.gov/recalls or on 1-888-327-4236.
Official source
- Recalling manufacturer
- GENERAL MOTORS CORP.
- Recall initiated by
- MFR
Everything on this page — the models listed, the build dates and the repair figures — comes from the manufacturer's filing to NHTSA and describes the vehicle line as a whole, not any individual car. Only the manufacturer can confirm whether a specific vehicle is affected, and whether its recall work has already been carried out. Check yours by VIN and read the official notice at nhtsa.gov/recalls.
Additional notes
Owner notification:owner notification began during september 1996.NOTE:OWNERS who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.ALSO contact the national highway traffic safety administration's auto safety hotline at 1800-424-9393.
Check your own vehicle
This page describes the recall, not any one car. To see which recalls cover a specific vehicle, search by make, model and year.
A VIN lookup here identifies your vehicle and shows recalls issued for that make, model and year. It cannot tell you what is still open on your individual car - only the manufacturer knows that. Search by VIN instead, or check your VIN at nhtsa.gov for whether a recall is still open on your individual car.